Peugeot 405

1987-1997 of release

Repair and operation of the car



Peugeot 405
+ 1. Maintenance instruction
- 2. Maintenance
   2.1. Technical characteristic
   + 2.2. Frequency of service
   + 2.3. Each 7 500 km
   + 2.4. Each 10 000 km or 6 months
   - 2.5. Each 20 000 km or 12 months
      2.5.1. Control of hoses of system of ventilation of a case of the engine
      2.5.2. Replacement of the fuel filter
      2.5.3. Check of turns of idling and composition of mix (SO)
      2.5.4. Replacement of spark plugs
      2.5.5. Check, adjustment and lubricant of coupling
      2.5.6. Check of a condition of a protective cover of a power shaft
      2.5.7. Check of a condition of lobbies and back brake shoes
      2.5.8. Check and adjustment of the emergency brake
      2.5.9. Check of a condition of a suspension bracket
      2.5.10. Check of drainage openings
   + 2.6. Each 30 000 km or 18 months
   + 2.7. Each 40 000 km or 2 years
   + 2.8. Each 60 000 km or 3 years
+ 3. Engines
+ 4. Fuel system
+ 5. Lubrication systems, coolings
+ 6. System of release
+ 7. Coupling
+ 8. Transmissions
+ 9. Power shafts
+ 10. Steering
+ 11. Suspension brackets
+ 12. Brake system
+ 13. Body
+ 14. Electric equipment


e1bd1949



2.5.2. Replacement of the fuel filter

GENERAL INFORMATION

PETROL ENGINES


Prevention

When working on fuel system it is necessary to observe extra care.


Replacement of the fuel filter is made through 30 000 km for carburetor models and 60 000 km for models with injection.

Carburetor models

The fuel filter is installed in a hose of supply of fuel between the pump and the carburetor in a motor compartment.

PERFORMANCE ORDER
1. For replacement of the fuel filter to remove collars from hoses, and then to remove hoses from the filter.
2. At installation of the filter to pay attention to an arrow on the filter case which shows the direction of a stream of the fuel passing through the filter that is to the fuel pump.
3. To check the fuel tank for a sediment of impurity and rainfall from the carburetor. To clear the tank as required.
4. Unions of fuel system on the tank:
      – the top hose – return to the tank;
      – an average hose – from the pump;
      – the lower hose – to an entrance opening of the carburetor.

Models with system of injection of fuel

The fuel filter is located under the car bottom, on the right side of the fuel tank. Shooters showed hoses of supply of fuel (A) and fastening of a bracket (B).

PERFORMANCE ORDER
1. To clamp a hose of supply of fuel from the filter, to remove collars from hoses, and then to remove hoses from the filter. To weaken a nut of fastening of a bracket of the filter and to extend the filter from a bracket.
2. At installation of the filter to pay attention to an arrow on the filter case which shows the direction of a stream of the fuel passing through the filter.
3. To install the new filter in a bracket and to fix by a nut then to establish collars and to remove a clip from a fuel hose.
4. To start the engine and to check connections of hoses with the filter for tightness.

DIESEL ENGINES

The filter should be replaced each 22 500 km.

PERFORMANCE ORDER
1. To remove the lower cover in the place of fastening of the filter.
2. To replace a filtrational tab and to check a condition of laying.
3. To fix a cover.
4. To start the engine and to check tightness.

On the homepage